UTILIZATION OF COAL GASIFICATION PRODUCER GAS FOR POWER GENERATION USING 10 KW SPARK IGNITION ENGINE

Authors

  • N. Nurhadi R&D Centre for Mineral and Coal Technology
  • M. Ade A. Efendi R&D Centre for Mineral and Coal Technology

DOI:

https://doi.org/10.30556/imj.Vol19.No1.2016.362

Keywords:

gasifier, coal, generator set (genset), internal combustion engine, spark ignition engine.

Abstract

Coal gasification is the process of converting coal into gas to ease its use and more environmentally friendly. Research and Development Center for Mineral and Coal Technology (tekMIRA) has been researching, designing, and developing a small-capacity gasifier with the brand of GasMin. This study discusses GasMin design and utilization for power generation using internal combustion engine type spark ignition engine. The result of laboratory analysis shows that the calorific value of producer gas was 1,013 kcal/Nm3, tar content was 4.04 mg/Nm3, particulate content was 11.17 mg/Nm3 and temperature of gas was 36oC. Based on characteristic of producer gas, it can be used for fuel in internal combustion engine. The internal combustion engine generator set (genset) used in this research was 10 kW spark ignition type. To be used for gas producer, some modifications were made on genset engine by replacing the function of the carburetor into mixing chamber for air and producer gas, and placed before mixing gas entering the combustion chamber.The results ofthis researchshow that the power generated was 4.8 kW, which was about 53% of maximum power on fuel. It isin accordance with the literature whichstates that de-rating of the genset engine ranges from 40-50%.

References

Affendi, M., Sugiyatno, Imam Djunaedi, Haifa Wahyu. 2010. Uji Variasi Beban Listrik dan Rasio Gas Hasil Gasifikasi Sekam Padi Pada Mesin Diesel Dual Fuel. Seminar Rekayasa Kimia Dan Proses Jurusan Teknik Kimia Fakultas Teknik Universitas Diponegoro Semarang, h. D01-1 –D01-6.

Alexe, F., Marculescu, C. and Cenus, V. 2016. Analysis of biomass and waste gasification lean syngases combustion for power generation using spark ignition engines. Waste Management, 47, p.133- 140.

Fernald, R.H. 2006. The present status of the producer gas power plant in the United States: Contributions to economic geology, part II. 2006 [Bulletin No. 316]. Washington: Government Printing Office; Available from: http://pubs.usgs. gov/bul/0316g/report.pdf.

Gai, Chao and Yuping Dong, 2012. Experimental study on non-woody biomass gasification in a downdraft gasifier. International Journal of Hydrogen Energy, 37, p. 4935-4944.

Gobbato, P., Masi, M. and Benetti, M., 2015. Performance analysis of a producer gas- fuelled heavy-duty SI engine at full-load operation. Energy Procedia, 82, p.149- 155.

Hasler, P. and Nussbaumer, T., 2000. Sampling and analysis of particles and tars from biomass gasifier. Biomass and Bioenergy, 18, p. 61-66.

Martínez J.D., Mahkamov, K., Andrade, R.V., Lora, E.S., 2012. Syngas production in downdraft biomass gasifiers and its application using internal combustion engines. Renewable Energy, 38(1), p.1- 9.

Raman, P. and Ram, N.K., 2013. Performance analysis of an internal combustion engine operated on producer gas, in comparison with the performance of the natural gas and diesel engines. Energy, 63, p. 317-333.

Raman, P., Ram, N.K. and Gupta, R., 2013. A dual fired downdraft gasifier system to produce cleaner gas for power generation: design, development, and performance analysis. Energy, 54, p. 302-314.

Reddy, R. and Reddy, P. 2014. Analysis of producer gas carburetor for different air- fuel ratios using CFD. International Journal of Research in Engineering and Technology, vol. 03-Special Issue: 03.

Salam, P. Abdul and S. C. Bhattacharya. 2006. A comparative study of charcoal gasification in two types of spouted bed reactors. Energy, 31, p. 228-243.

Sofaeti,Y. 2013. Pengembangan rancang bangun gasifier batubara mini untuk menunjang ketersediaan energi di UKM dan pengganti BBM pada mesin generator listrik 1 kW. Laporan Teknik, Puslitbang Teknologi Mineral dan Batubara.

Son, Young-il, Sang Jun Yoon, Yong Ku Kim, and Jae-goo Lee. 2011. Gasification and power generation characteristics of woody biomass utilizing a downdraft gasifier. Biomass and Bioenergy 35(10), p. 4215-4220.

Sridhar, G. and Yarasu, R.B., 2010. Facts about producer gas engine, Paths to sustainable energy, Dr Artie Ng (Ed.), ISBN: 978-953-307-401-6, InTech, Available from: http://www.intechopen.com/books/pathst o-sustainable-energy/facts-about- producer-gas-engine.

Tsiakmakis, S., Mertzis, D., Dimaratos, A., Toumasatos, Z., and Samaras, Z., 2014. Experimental study of combustion in a spark ignition engine operating with producer gas from various biomass feedstocks. Fuel, 122, p.126-139.

Downloads

Published

2017-09-17