THE INFLUENCE OF STEAM DRYING PROCESS ON COMBUSTION BEHAVIOR OF INDONESIAN LOW-RANK COALS
DOI:
https://doi.org/10.30556/imj.Vol23.No2.2020.1105Keywords:
low rank coal, drying, calorific value, moisture, combustionAbstract
Steam drying process of the Low Rank Coals (LRCs) has been conducted to produce coal which is comparable with the High Rank Coal (HRC). Characterization of the raw and dried coals was carried out through proximate, ultimate, calorific value, Fourier Transform Infrared (FTIR) spectroscopy and Thermo Gravimetry-Differential Thermal Analysis (TG-DTA) to study the combustion behavior of the coals. This study used Indonesian low rank coals coming from Tabang (TKK coal) and Samurangau (SP coal), East Kalimantan. The results indicate that the calorific value of the dried coals increases significantly due to the decrease in moisture content of the coal. The FTIR spectrums show that the methylene-ethylene (RCH3/CH2) and aromaticity-aliphaticity ratios (Rar/al) of the dried coals increased while the ratio of RCO/ar decreased which reflect that the rank of the coals increased equivalent to the high rank coal (bituminous). Meanwhile, the TG-DTA indicates that the ignition temperature (Tig) and combustion rate (Rmax) of the dried coals increased. This analysis expresses that the dried coals produced by steam drying process have better combustion behavior due to the higher calorific value than those of the raw coals.
References
Ahmed, M., Blesa, M. J., Juan, R. and Vandenberghe, R. B. (2003) “Characterisation of an Egyptian coal by Mossbauer and FT-IR spectroscopy⋆,” Fuel, 82(14), pp. 1825–1829. doi: 10.1016/S0016-2361(03)00131-5.
Ávila, I., Crnkovic, P. M., Luna, C. M. R. and Milioli, F. E. (2017) “Use of a fluidized bed combustor and thermogravimetric analyzer for the study of coal ignition temperature,” Applied Thermal Engineering, 114, pp. 984–992. doi: 10.1016/j.applthermaleng.2016.11.171.
Chen, Z., Agarwal, P. K. and Agnew, J. B. (2001) “Steam drying of coal. Part 2. Modeling the operation of a fluidized bed drying unit,” Fuel, 80(2), pp. 209–223. doi: 10.1016/S0016-2361(00)00081-8.
Cheng, Q., Via, B., Wang, J. and Zondlo, J. (2014) “Primary study of woody biomass and coal for energy production investigated by TGA-FTIR analysis,” BioResources, 9(2). doi: 10.15376/biores.9.2.2899-2906.
Deguchi, T., Shigehisa, T. and Shimasaki, K. (1999) “Study on upgraded brown coal process for Indonesian low rank coals,” in Proc. International Conference on Clean and Efficient Coal Technolgy in Power Generation. Indonesia, pp. 176–180.
Fei, Y., Aziz, A. A., Nasir, S., Jackson, W. R., Marshall, M., Hulston, J. and Chaffee, A. L. (2009) “The spontaneous combustion behavior of some low rank coals and a range of dried products,” Fuel, 88(9), pp. 1650–1655. doi: 10.1016/j.fuel.2009.03.017.
Fujitsuka, H., Ashida, R. and Miura, K. (2013) “Upgrading and dewatering of low rank coals through solvent treatment at around 350°C and low temperature oxygen reactivity of the treated coals,” Fuel, 114, pp. 16–20. doi: 10.1016/j.fuel.2012.12.010.
Ge, L., Zhang, Y., Xu, C., Wang, Z., Zhou, J. and Cen, K. (2015) “Influence of the hydrothermal dewatering on the combustion characteristics of Chinese low-rank coals,” Applied Thermal Engineering, 90, pp. 174–181. doi: 10.1016/j.applthermaleng.2015.07.015.
Godfrey, B. (2010) “Recent developments in innovative drying technologies,” in International Symposium on the Sustainable Use of Low Rank Coals. Melbourne, Australia: The Department of Primary Industries (DPI), p. 31.
Katalambula, H. and Gupta, R. (2009) “Low-grade coals: A review of some prospective upgrading technologies,” Energy & Fuels, 23(7), pp. 3392–3405. doi: 10.1021/ef801140t.
Liao, J., Fei, Y., Marshall, M., Chaffee, A. L. and Chang, L. (2016) “Hydrothermal dewatering of a Chinese lignite and properties of the solid products,” Fuel, 180, pp. 473–480. doi: 10.1016/j.fuel.2016.04.027.
Liu, M., Duan, Y. and Ma, G. (2015) “The effect of organic solvent thermal treatment on the physicochemical properties of lignite,” Asia-Pacific Journal of Chemical Engineering, 10(5), pp. 724–733. doi: 10.1002/apj.1910.
Mahidin, Ogaki, Y., Usui, H. and Okuma, O. (2003) “The advantages of vacuum-treatment in the thermal upgrading of low-rank coals on the improvement of dewatering and devolatilization,” Fuel Processing Technology, 84(1–3), pp. 147–160. doi: 10.1016/S0378-3820(03)00052-3.
Marinov, S. P., Gonsalvesh, L., Stefanova, M., Yperman, J., Carleer, R., Reggers, G., Yürüm, Y., Groudeva, V. and Gadjanov, P. (2010) “Combustion behaviour of some biodesulphurized coals assessed by TGA/DTA,” Thermochimica Acta, 497(1–2), pp. 46–51. doi: 10.1016/j.tca.2009.08.012.
Mursito, A. T., Hirajima, T., Sasaki, K. and Kumagai, S. (2010) “The effect of hydrothermal dewatering of Pontianak tropical peat on organics in wastewater and gaseous products,” Fuel, 89(12), pp. 3934–3942. doi: 10.1016/j.fuel.2010.06.035.
Mursito, A. T., Hirajima, T. and Sasaki, K. (2011) “Alkaline hydrothermal de-ashing and desulfurization of low quality coal and its application to hydrogen-rich gas generation,” Energy Conversion and Management, 52(1), pp. 762–769. doi: 10.1016/j.enconman.2010.08.001.
Niksa, S. and Krishnakumar, B. (2015) “Predicting the steam drying behavior of brown coals and lignites,” Fuel, 159, pp. 345–353. doi: 10.1016/j.fuel.2015.06.031.
Nonaka, M., Hirajima, T. and Sasaki, K. (2011) “Upgrading of low rank coal and woody biomass mixture by hydrothermal treatment,” Fuel, 90(8), pp. 2578–2584. doi: 10.1016/j.fuel.2011.03.028.
Parshetti, G. K., Quek, A., Betha, R. and Balasubramanian, R. (2014) “TGA–FTIR investigation of co-combustion characteristics of blends of hydrothermally carbonized oil palm biomass (EFB) and coal,” Fuel Processing Technology, 118, pp. 228–234. doi: 10.1016/j.fuproc.2013.09.010.
Rao, Z., Zhao, Y., Huang, C., Duan, C. and He, J. (2015) “Recent developments in drying and dewatering for low rank coals,” Progress in Energy and Combustion Science, 46, pp. 1–11. doi: 10.1016/j.pecs.2014.09.001.
Sahu, S. G., Sarkar, P., Chakraborty, N. and Adak, A. K. (2010) “Thermogravimetric assessment of combustion characteristics of blends of a coal with different biomass chars,” Fuel Processing Technology, 91(3), pp. 369–378. doi: 10.1016/j.fuproc.2009.12.001.
Sakaguchi, M., Laursen, K., Nakagawa, H. and Miura, K. (2008) “Hydrothermal upgrading of Loy Yang Brown coal - Effect of upgrading conditions on the characteristics of the products,” Fuel Processing Technology, 89(4), pp. 391–396. doi: 10.1016/j.fuproc.2007.11.008.
Shigehisa, T., Deguchi, T., Shimasaki, K. and Makino, E. (2000) “Development of UBC process,” in Proc. International Conference on Fluid and Thermal Energy Conversion. Indonesia, p. 16.
Song, H., Liu, G., Zhang, J. and Wu, J. (2017) “Pyrolysis characteristics and kinetics of low rank coals by TG-FTIR method,” Fuel Processing Technology, 156, pp. 454–460. doi: 10.1016/j.fuproc.2016.10.008.
Suggate, R. P. and Dickinson, W. W. (2004) “Carbon NMR of coals: the effects of coal type and rank,” International Journal of Coal Geology, 57(1), pp. 1–22. doi: 10.1016/S0166-5162(03)00116-2.
Tian, B., Qiao, Y., Tian, Y., Xie, K., Liu, Q. and Zhou, H. (2016) “FTIR study on structural changes of different–rank coals caused by single/multiple extraction with cyclohexanone and NMP/CS 2 mixed solvent,” Fuel Processing Technology, 154, pp. 210–218. doi: 10.1016/j.fuproc.2016.08.035.
Umar, D. F., Daulay, B., Usui, H. and Suprapto, S. (2005) “Upgrading of indonesian low rank coal by steam drying method,” Indonesian Mining Journal, 8(1), pp. 21–26.
Umar, D. F. (2015) “Low rank coal upgrading: Effect of upgrading conditions on characterization of the product,” in Proceedings of BIT’s 4th Annual International Symposium of Clean Coal Technology (CCT 2015). Xián, China: CCT, p. 24.
Umar, D. F. (2016) “Sifat pembakaran batubara hasil proses upgrading dengan teknologi hot water drying,” in Santoso, B. et al. (eds.) Prosiding Kolokium Puslitbang Teknologi Mineral dan Batubara 2016. Bandung: Puslitbang tekMIRA, pp. 49–61.
Umar, D. F. (2019) “Low rank coal upgrading,” in Sihombing, F. M. H. and Yulman, R. (eds.) Proceedings of The 11th MGEI Annual Convention “Unlocking Concealed and Complex Deposits.” Bogor: IAGI & MGEI, pp. 58–72.
Umar, D. F., Santoso, B. and Usui, H. (2007) “The Effect of Upgrading Processes on Combustion Characteristics of Berau Coal,” Energy & Fuels, 21(6), pp. 3385–3387. doi: 10.1021/ef070061j.
Umar, D. F., Shimojo, M. and Madiutomo, R. M. N. (2018) “Evaluation of combustion behaviour for Indonesian low-rank coals treated hydrothermally,” Indonesian Mining Journal, 21(2), pp. 127–139. doi: 10.30556/imj.Vol21.No2.2018.919.
Umar, D. F., Usui, H. and Daulay, B. (2005) “Effects of processing temperature of hot water drying on the properties and combustion characteristics of an Indonesian low rank coal,” Coal Preparation, 25(4), pp. 313–322. doi: 10.1080/07349340500444554.
Wafid, M. (2019) “Country report-Indonesia,” in 17th Afoc Council Meeting. Langkawi: AFOC.
Wang, S., Chen, H. and Zhang, X. (2020) “Transformation of aromatic structure of vitrinite with different coal ranks by HRTEM in situ heating,” Fuel, 260, p. 116309. doi: 10.1016/j.fuel.2019.116309.
Wu, J., Liu, J., Zhang, X., Wang, Z., Zhou, J. and Cen, K. (2015) “Chemical and structural changes in XiMeng lignite and its carbon migration during hydrothermal dewatering,” Fuel, 148, pp. 139–144. doi: 10.1016/j.fuel.2015.01.102.
Yu, J., Tahmasebi, A., Han, Y., Yin, F. and Li, X. (2013) “A review on water in low rank coals: The existence, interaction with coal structure and effects on coal utilization,” Fuel Processing Technology, 106, pp. 9–20. doi: 10.1016/j.fuproc.2012.09.051.
Zhang, Y., Wu, J., Wang, Y., Miao, Z., Si, C., Shang, X. and Zhang, N. (2016) “Effect of hydrothermal dewatering on the physico-chemical structure and surface properties of Shengli lignite,” Fuel, 164, pp. 128–133. doi: 10.1016/j.fuel.2015.09.055.
Zodrow, E. L., D’Angelo, J. A., Helleur, R. and Šimůnek, Z. (2012) “Functional groups and common pyrolysate products of Odontopteris cantabrica (index fossil for the Cantabrian Substage, Carboniferous),” International Journal of Coal Geology, 100, pp. 40–50. doi: 10.1016/j.coal.2012.06.002.
Downloads
Published
Issue
Section
License
Indonesian Mining Journal provides immediate open access to its content on the principle that making research freely available to the public to supports a greater global exchange of knowledge.
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.